Product ID:RHO-SOLV 7228
MSDS Date:06/07/1995
FSC:6850
NIIN:00N078726
MSDS Number: CGGMQ

RHO-CHEM CORP

425 ISIS AVE
INGLEWOOD, CA 90301
US

Emergency Phone: 800-535-5053

Info Phone: 213-776-6233

Preparer: STEPHEN B. FULTON

Cage: 21414

RHO-CHEM CORP

6021 INGELEWOOD, CA 90301-2009 US

Telephone: 213-776-6233

Cage: 21414

(ORAL,RAT) >8

CAS: 64742-89-8

Fraction By Weight: 40%

OSHA PEL 300 PPM (MFR)

ACGIH TLV: 300 PPM (MFR)

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 30%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM;300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

(ORAL,RAT) 5,000 MG/KG.

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 15%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA 313).

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 15%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM;500 STEL

>0.5 MG/L.

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <0.1%

OSHA PEL SEE 1910.1028

ACGIH TLV: 10 PPM

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

(EVID BY LOSS OF APPETITE, JAUN (YELLOWISH

RTECS: 9999999ZZ

PROD CNTNS CHEM KNOWN TO STATE OF

RTECS: 9999999ZZ

TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPRO

RTECS: 9999999ZZ

CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS

RTECS: 9999999ZZ

INDIVIDUAL INGREDIENTS HEALTH HAZARDS CONTACT NEHC .

RTECS: 9999999ZZ

INDUCE VOMIT. IF VOMIT OCCURS SPONT, KEEP

RTECS: 9999999ZZ

IF >2 ML/KG HAS BEEN

RTECS: 9999999ZZ

INDUCED W/SUPERVISION. IF SYMPS SUCH AS LOSS OF GAG

RTECS: 9999999ZZ

LAVAGE SHOULD BE CONSIDERED, USING CUFFED

RTECS: 9999999ZZ

FOG MAY BE USEFUL IN SUPPRESSING VAP CLOUD; CNTN

RTECS: 9999999ZZ

VESSELS. SOAK UP RESIDUE W/ABSORB SUCH AS CLAY,

RTECS: 9999999ZZ

PROPER DISP. FLUSH AREA W/WATER TO REMOVE TRACE

RTECS: 9999999ZZ

UP W/ABSORB MATL & PLACE IN NON-LEAKING CNTNRS; SEAL

RTECS: 9999999ZZ

OIL - SPILLS INTO/LEADING TO SURF WATERS THAT CAUSE

RTECS: 9999999ZZ

BEEN EMPTIED, CAN CNTN EXPLO VAPS. DO NOT CUT,

RTECS: 9999999ZZ

CNTNRS. DO NOT PRESSURIZE DRUM CNTNRS TO EMPTY THEM.

RTECS: 9999999ZZ

FIXED EQUIP. BOND & GROUND TRANSFER CNTNRS & EQUIP.

RTECS: 9999999ZZ

COLLECT IN LOW AREAS SUCH AS PITS, DEGREASERS, STOR

RTECS: 9999999ZZ

WHERE VAPS OF PROD ARE SUSPECTED UNLESS NIOSH APPRVD

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAY CAUSE IRRIT TO NOSE,
THROAT & RESP TRACT; VAPS ARE MOD TOX. HIGH VAP CONCS MAY PRDCE CNS
DEPRESS EVID BY GIDD, HDCH, DIZZ & NAUS, UNCON & DEATH MAY OCCUR.
SKIN:MOD IRRIT. PRLNG/RPTD CO NT CAN RSLT IN DEFAT & DRYING, WHICH
MAY RSLT IN IRRIT & DERM. TOLUENE MAY BE ABSORBED, CONTRIBUTING
TO(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OVERALL EXPOS. EYES:MOD TO SEV IRRIT.
INGEST:MOD TOX & MAY BE HARMFUL. MAY RSLT IN VOMIT; ASPIR OF
VOMITUS INTO LUNGS MUST BE AVOIDED, AS EVEN SM QTYS MAY RLST IN
ASPIR PNEUM (EVID BY COUGH, LABORED BRTHG & CYANOSIS, DEATH MAY
OCCUR). MAY PRDCE CNS DEPRESS, LOW BLOOD PRESS, RAPID HEART BEAT &
LIVER DMG (ING 7)
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN & RESP
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS WHILE
HOLDING LIDS OPEN. GET MED ATTN. SKIN:REMOVE CONTAM CLTHG & SHOES.
FLUSH W/WATER, THEN WASH EXPOS AREA W/SOAP & WATER. IF IRRIT
OCCURS, GET MED ATTN. LAUNDER CONTAM CLTHG PRIOR TOREUSE.
INHAL:REMOVE TO FRESH AIR. HAVE QUALIFIED INDIVIDUAL PROVIDE OXYG
IF BRTHG IS DFCLT. ADMIN ARTF RESP IF NOT BRTHG. GET MED ATTN.
INGEST:DO NOT (ING 12)

Flash Point Method:TCC
Flash Point:<70F,<21C
Lower Limits:1%
Upper Limits:12%
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEM/CO*2. DO NOT USE
DIRECT STREAM OF WATER; PROD WILL FLOAT & CAN BE REIGNITED ON WATER
SURF.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . CLEAR FIRE AREA OF UNPROTECTED PERSONNEL.
Unusual Fire/Explosion Hazard:CNTNRS & CNTNR AREAS EXPOS TO INTENSE
HEAT FROM FIRES/DIRECT FLAME CONT SHOULD BE COOLED W/WATER TO PVNT
VAP-PRESS BUILD-UP, WHICH COULD RSLT IN CNTNR RUPTURE.

Spill Release Procedures:FLAMM. ELIM ALL IGNIT SOURCES. HNDLG EQUIP
MUST BE GROUNDED TO PVNT SPARKING. LG SPILLS:ISOLATE HAZ AREA &
DENY ENTRY TO UNNEC PERS. WEAR APPROP NIOSH APPRVD RESP & PROT
CLTHG. SHUT OFF SOURCE OF LEAK ONLY IF SAFE TO DO SO. DIKE & CNTN.
WATER(ING 16)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:EXTING PILOT LIGHTS & CIGARETTES &
TURN OFF SOURCES OF IGNIT PRIOR TO USE & UNTIL ALL VAPS ARE GONE.
EXERCISE REAS CARE & CAUT. AVOID SKIN CONTACT.
Other Precautions:SURFS THAT ARE SUFFICIENTLY HOT MAY IGNITE EVEN LIQ
PROD IN ABSENCE OF SPKS/FLAME. VAPS MAY ACCUM & TRAVEL TO IGNIT
SOURCES DIST FROM HNDLG SITE; FLASH-FIRE CAN RSLT. KEEP CNTNRS CLSD
WHEN NOT IN USE; CNTNRS, EVEN THOSE THAT HAVE (ING 21)

Respiratory Protection:AVOID PRLNG/RPTD BRTHG OF VAPS. IF EXPOS
MAY/DOES EXCEED OCCUP EXPOS LIMS, USE NIOSH APPRVD RESP AS REQD TO
PVNT OVEREXP. I/A/W 29 CFR 1910.134, USE EITHER NIOSH APPRVD
ATM-SUPPLYING RESPIRATOR/AIR-PU RIFYING RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:MAINTAIN WORK PLACE VAP CONCS BELOW OCCUP EXPOS LIMS. DO
NOT USE IN CLSD/CONFINED SPACE. OPEN DOORS & WINDOWS. (SUPDAT)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR OTHER CLOTHING AS REQUIRED TO MINIMIZE CONTACT.
Work Hygienic Practices:WASH HANDS PRIOR TO EATING, DRINKING/USING
RESTROOM. DO NOT WEAR CONTACT LENSES. DO NOT EAT, DRINK/SMOKE IN
WORK AREA.
Supplemental Safety and Health
WASTE DISP METH:CHARACT OF TOX CHARACT LEACHING PROC (TCLP). INGS 3 &
2:HAZ WASTE CODE F005 WHEN SPENT, AS PER 40 CFR 261.31. REFER TO
LATEST EPA & STATE REGS REGARDING PROPER DISP. VENT:USE EXPLO-PRO
OF VENT TO MAINTAIN EXPOS BELOW RELS. TO DETERMINE EXPOS LEVEL(S),
MONITORING SHOULD BE PERFORMED REGULARLY.

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:33.29 @20C
Vapor Density:3.1
Spec Gravity:0.792 (H*2O=1)
VOC Pounds/Gallon:792
Evaporation Rate & Reference:2 (N-BUTYL ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:CLEAR, LIGHT-COLORED LIQUID; PUNGENT, HYDROCARBON
ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, STORAGE OR HANDLING
IN ALUMINUM EQUIPMENT HOTTER THAN 120F.
Hazardous Decomposition Products:CARBON MONOXIDE & UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED DURING COMBUSTION.

Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . UNDER
EPA-RCRA 40 CFR 261.21, IF PROD BECOMES WASTE, IT WOULD BE
IGNITABLE HAZ WASTE, #D001. INGS 5 & 2:UNDER EPA-RCRA 40 CFR
261.24, WASTE IS HAZ, #'S D018 & D035, RESPECTIVELY, IF IT
EXHIBITS(SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.